What kind of oil to pour into the engine of the oka walk-behind tractor

THEN every 25. 30 hours of operation of the walk-behind tractor

  • Carry out daily maintenance work
  • Check the tightness of the gas hose connection. Leakage of gasoline through the hose connections is not allowed.
  • Check the oil level in the gearbox, top up to 1.5. 2 liters. (See Oil Change). Gear oil: TCn-10 GOST 23652-79 or any other gear oil complying with SAE: 80… 85W API: GL3… GL4

THEN every 100 hours of operation of the walk-behind tractor

Suitable for transmission oil: TCn-10 GOST 23652-79 or any other transmission oil that meets SAE: 80 85W API: GL3 GL4.

What kind of oil to pour into the engine of the oka walk-behind tractor

  • daily maintenance;
  • maintenance every 25-30 hours of operation;
  • maintenance every 50 hours of operation;
  • oil change in transmission every 100 hours of operation;
  • storage maintenance

Cultivating the land with a cultivator after sharpening mills, Oleo-Mac MH 197 RK

Engine maintenance is carried out in accordance with the requirements of the engine operation manual.

Daily maintenance of the walk-behind tractor

  • Remove dirt, dust and oil from the outer surfaces of the walk-behind tractor with a rag.
  • Check the reliability of fastening of the available parts of the walk-behind tractor and, if necessary, tighten it: assembly units and parts must be fixed.
  • Visually check the condition of the wiring. no exposure of the wiring is allowed!
  • Visually check the condition of the V-belt transmission belts. no stratification of belts is allowed!
  • Check the reliability of the attachment of the mounted (trailed) unit, it must be securely fastened and fixed.
  • Check the tire pressure when working on wheels: operating rate. 1.8 2 kgf / cm².

You will need: rags, electrical tape, tire gauge.

THEN every 50 hours of operation of the walk-behind tractor

  • Drain gasoline from fuel tank and engine oil
  • Install a container to the right of the walk-behind tractor
  • Unscrew the plug, and, tilting the uniaxial tractor to the right, drain the oil from the gearbox into the placed container.
  • Put a single-axle tractor on wheels and fill the gearbox with oil in the amount of 1.5. 2 liters.
  • Screw in the plug. Fill the fuel tank and engine oil with gasoline.

You will need: Funnel, container, rags, TCn-10 GOST 23652-79 oil or any other gear oil that meets SAE: 80 85W API: GL3 GL4.

THAT during storage of an unconserved walk-behind tractor (up to 3 months)

  • By external inspection, check the condition of the V-belt transmission belts, the absence of leakage of gasoline and oil (once a month)
  • Start the engine and run at idle mode for 3-5 minutes (once a month)
  • Change the oil in the gearbox (once every 18 months)

Conservation

  • Preserve the engine according to the engine manual.
  • Remove dust and dirt from the single-axle tractor. Parts of the walk-behind tractor that do not have paint and varnish coatings (protruding parts of the engine crankshaft, shift shaft and gearbox output shaft), lubricate with conservation oil K-17 GOST 10877-76.

Oil for single-axle tractor Oka

Volume Oil type
Crankcase 1,3 Automotive motor oil for carburetor engines M-53 / 10G1 or M-63 / 12G1, or any oil that meets API requirements: SF, SG, SH and SAE: 10W-30, 15W-30
Walk-behind tractor reducer 1.8 Transmission oil TAD-17I, TAP-15V and others GOST 23652-79

The frequency of oil change in the Oka walk-behind tractor

Gearbox oil change intervals During break-in first oil change after 25 operating hours After every 25 operating hours Check the oil level in the gearbox. Add up to 1.5. 2 L every 50 hours of operation. Change gearbox oil
The frequency of oil change in the engine of the Oka walk-behind tractor (excerpts from the operating instructions of the main engine manufacturers) Briggs Stratton (brigs) First 5 hours. Change oil. Every 8 hours or daily. Check oil level. Every 50 hours or every season. Change oil.
Honda (Honda) Lifan (Lifan) Checking the oil level. with every use. Change of oil. the first month or after 20 hours of work, thereafter. every 6 months or after 100 hours of operation
Robin Subaru (Subaru) Checking the level and adding engine oil. each time the engine is used (add oil to the maximum mark). Engine oil change: First change after 20 hours of operation; later. every 100 hours of operation

What kind of oil to fill in a single-axle tractor OKA

What oil to pour into the engine and gearbox of the Oka walk-behind tractor should be known to every owner of this technique. Butter. it is a key factor for the perfect operation of the motor and gearbox, under load conditions, when working the land. After all, work is on the ground. hard work, and motor vehicles work under extreme stress.

Therefore, the oil in the walk-behind tractor needs to be changed much more often than in the car. The most correct advice on the choice of oil is the recommendations of the manufacturers of the walk-behind tractor and the engine to it. Therefore, we turn to the user manual for Oka and to the operating instructions for the engines used.

Manufacturer of motoblocks MB-1 Oka. JSC Kaluga engine, Kaluga, st. Moscow, 247

Official website of the manufacturer of the Oka MB-1 walk-behind tractor. http://www.kadvi.ru

Operation manual for single-axle tractor Oka MB-1D1 (2, 3) M and its modifications download

What kind of oil to fill in a single-axle tractor Oka (gearbox, engine)

Changing the oil in the gearbox of the Oka walk-behind tractor

operations and specifications Tools, fixtures, materials
Drain gasoline from fuel tank and engine oil Capacity
Install a container to the right of the walk-behind tractor
Unscrew plug 1 (Figure 6) and, tilting the single-axle tractor to the right, drain the oil from the gearbox into the placed container.
Place a single-axle tractor on wheels and fill the gearbox with oil of the brand indicated in the table above, in a volume of 1.5. 2.0 liters. Funnel, container, oil, rags
Screw in the plug 1. Fill the fuel tank with gasoline and oil the engine

Oka motor-block engine oil recommended by manufacturers.

Motoblock engine make Manufacturer’s Recommended Engine Oil
summer winter service class
Robin Subaru (Subaru) SAE 10W-30. in temperate climates SAE 5W-30. in cold regions Automotive engine oil; class SE or higher (SG, SH or SJ recommended)
Honda (Honda) SAE 10W-30 is recommended for use at all temperatures. If you wish to use seasonal oil, select the appropriate viscosity grade based on the average temperature in your area. SG, SF.
Lifan (Lifan) SAE-30 SAE-10W-30. all-season
Briggs Stratton (brigs) Briggs Stratton recommends the use of synthetic oil when operating in temperatures below 0 ° C. If you do not have synthetic oil, you can use Briggs Stratton 10W-30 non-synthetic oil, part number 998208 Note: Synthetic oil that meets the ILSAC GF-2 certification mark, API and API service symbol labeled “SJ / CF ENERGY CONSERVING” and above can be apply at any temperature. Change synthetic oil as usual. Air cooled engines heat up faster than car engines. Using non-synthetic thickened oil (5W-30, 10W-30, etc.) at temperatures above 4 ° C will result in high oil consumption. If using such oil, check the oil level more often. SF, SG, SH, SJ or above
DM-1-01 (JSC Kaluga Engine) М63 / 12Г1 or М53 / 10Г1 GOST 10541-78, oil corresponding to API requirements: SF; SG; SH and SAE: 10W30; 15W30
DM-1K Instruction from OJSC “Red October” M10GI, M12GI TU 38.10148-85 M63 / 12G1 or M53 / 10G1 GOST 10541-78,

For more information about oil in the motoblock gearbox, see here.

Video. preparation of the Oka walk-behind tractor for work

What kind of oil to fill in a single-axle tractor OKA

What oil to pour into the engine and gearbox of the Oka walk-behind tractor should be known to every owner of this technique. Oil is a key factor for the perfect operation of the engine and gearbox, under load conditions, when working the land. After all, work on the ground is a difficult task, and motor vehicles work under extreme loads.

kind, pour, engine, walk-behind

Therefore, the oil in the walk-behind tractor needs to be changed much more often than in the car. The most correct advice on the choice of oil is the recommendations of the manufacturers of the walk-behind tractor and the engine to it. Therefore, we turn to the user manual for Oka and to the operating instructions for the engines used.

Manufacturer of MB-1 Oka motoblocks. JSC Kaluga engine, Kaluga, st. Moscow, 247

The official website of the manufacturer of the Oka MB-1 walk-behind tractor. http://www.kadvi.ru

Operation manual for single-axle tractor Oka MB-1D1 (2, 3) M and its modifications download

What kind of oil to fill in a single-axle tractor OKA

What oil to pour into the engine and gearbox of the Oka walk-behind tractor should be known to every owner of this technique. Oil is a key factor for the perfect operation of the engine and gearbox, under load conditions, when working the land. After all, work on the ground is a difficult task, and motor vehicles work under extreme loads.

Therefore, the oil in the walk-behind tractor needs to be changed much more often than in the car. The most correct advice on the choice of oil is the recommendations of the manufacturers of the walk-behind tractor and the engine to it. Therefore, we turn to the user manual for Oka and to the operating instructions for the engines used.

Manufacturer of MB-1 Oka motoblocks. JSC Kaluga engine, Kaluga, st. Moscow, 247

The official website of the manufacturer of the Oka MB-1 walk-behind tractor. http://www.kadvi.ru

kind, pour, engine, walk-behind

Operation manual for single-axle tractor Oka MB-1D1 (2, 3) M and its modifications download

Oka motor-block engine oil recommended by manufacturers.

Motoblock engine make Manufacturer’s Recommended Engine Oil
summer winter service class
Robin Subaru (Subaru) SAE 10W-30. in temperate climates SAE 5W-30. in cold regions Automotive engine oil; class SE or higher (SG, SH or SJ recommended)
Honda (Honda) SAE 10W-30 is recommended for use at all temperatures. If you wish to use seasonal oil, select the appropriate viscosity grade based on the average temperature in your area. SG, SF.
Lifan (Lifan) SAE-30 SAE-10W-30. all-season
Briggs Stratton (brigs) Briggs Stratton recommends the use of synthetic oil when operating in temperatures below 0 ° C. If you do not have synthetic oil, you can use Briggs Stratton 10W-30 non-synthetic oil, part number 998208 Note: Synthetic oil that meets the ILSAC GF-2 certification mark, API and API service symbol labeled “SJ / CF ENERGY CONSERVING” and above can be apply at any temperature. Change synthetic oil as usual. Air cooled engines heat up faster than car engines. Using non-synthetic thickened oil (5W-30, 10W-30, etc.) at temperatures above 4 ° C will result in high oil consumption. If using such oil, check the oil level more often. SF, SG, SH, SJ or above
DM-1-01 (JSC Kaluga Engine) М63 / 12Г1 or М53 / 10Г1 GOST 10541-78, oil corresponding to API requirements: SF; SG; SH and SAE: 10W30; 15W30
DM-1K Instruction from OJSC “Red October” M10GI, M12GI TU 38.10148-85 M63 / 12G1 or M53 / 10G1 GOST 10541-78,

For more information about oil in the motoblock gearbox, see here.

Lawn Mower Oil Guide: What Type of Lawn Mower Oil Should I Use? | eReplacementParts.com

Video. preparing the Oka walk-behind tractor for work

What oil to pour into the gearbox of the oka walk-behind tractor

Engine maintenance is carried out in accordance with the requirements of the engine operation manual.

Oil for single-axle tractor Oka

Volume Oil type
Crankcase 1,3 Automotive motor oil for carburetor engines M-53 / 10G1 or M-63 / 12G1, or any oil that meets API requirements: SF, SG, SH and SAE: 10W-30, 15W-30
Walk-behind tractor reducer 1.8 Transmission oil TAD-17I, TAP-15V and others GOST 23652-79

The frequency of oil change in the Oka walk-behind tractor

Gearbox oil change intervals During break-in first oil change after 25 operating hours After every 25 operating hours Check the oil level in the gearbox. Top up to 1.5. 2 l After every 50 hours of operation. Change the oil in the gearbox
The frequency of oil change in the engine of the Oka walk-behind tractor (excerpts from the operating instructions of the main engine manufacturers) Briggs Stratton (brigs) First 5 hours. Change oil. Every 8 hours or daily. Check oil level. Every 50 hours or every season. Change oil.
Honda (Honda) Lifan (Lifan) Check Oil Level. Every Use. Oil change. first month or after 20 hours of operation, thereafter. every 6 months or after 100 hours of operation
Robin Subaru (Subaru) Checking the level and adding engine oil. every time the engine is used (add oil to the maximum mark). Engine oil change: First change after 20 operating hours; subsequently every 100 operating hours

Conservation

  • Preserve the engine according to the engine manual.
  • Remove dust and dirt from the single-axle tractor. Parts of the walk-behind tractor that do not have paint and varnish coatings (protruding parts of the engine crankshaft, shift shaft and gearbox output shaft), lubricate with conservation oil K-17 GOST 10877-76.

THEN every 100 hours of operation of the walk-behind tractor

Suitable for transmission oil: TCn-10 GOST 23652-79 or any other transmission oil that meets SAE: 80 85W API: GL3 GL4.

Changing the oil in the gearbox of the Oka walk-behind tractor

operations and specifications Tools, fixtures, materials
Drain gasoline from fuel tank and engine oil Capacity
Install a container to the right of the walk-behind tractor
Unscrew plug 1 (Figure 6) and, tilting the single-axle tractor to the right, drain the oil from the gearbox into the placed container.
Place a single-axle tractor on wheels and fill the gearbox with oil of the brand indicated in the table above, in a volume of 1.5. 2.0 liters. Funnel, container, oil, rags
Screw in the plug 1. Fill the fuel tank with gasoline and oil the engine